our products

D&Q Mining is a high-tech company integrating R&D, production and sales. It provides mature products and solutions such as crushers, sand making, milling equipment, mobile crushing stations, etc., for aggregate, mining and waste recycling.

pyrite flotation concentrate

Pyrite Flotation Froth Flotation (Sulphide & Oxide

Can you list the factors affects the floatability of pyrite from refractory low grade ore.I used a Wemco lab flotation cell and aimed on analysing factors like collector dosages (PAX), Activator (Copper sulphate),MIBC,pH and others like pulp density and particle size (70 and 150 microns) .However

More

Leaching of the arsenopyrite/pyrite flotation concentrates

The arsenopyrite/pyrite flotation concentrate, mainly studied in the hydrochloric acid medium, decomposed through the non–oxidative chemical dissolution reaction and the reductive decomposition reaction for the arsenopyrite and pyrite components, respectively. Desulphurization levels below 65% were achieved at pH

More

A study on the effect of active pyrite on flotation of

respectively. Under the optimum conditions, the grade of final concentrate increased from 0.94% to 21.3% with three cleaner stages. Keywords: Active pyrite, Chalcopyrite, Collector, Flotation, Optimization 1. Introduction Chalcopyrite is often associated with pyrite which is the most undesirable mineral with the same

More

(PDF) Recovery of pyrite from copper tailings by flotation

The results obtained both at laboratory and industrial scale showed that it is possible to produce concentrates with a pyrite grade over 90% and recoveries over 70% in a flotation circuit that

More

The depression of pyrite in selective flotation by

Pyrite is a major gangue mineral associated with galena and other valuable minerals, and it is necessary to selectively remove pyrite to upgrade the lead concentrate by froth flotation.

More

PYRITE ROASTING, AN ALTERNATIVE TO SULPHUR BURNING

important process figures are the reaction temperature and the concentrate throughput. The pyrite concentrates can be classified as: Type Composition Grain Size Pyrite Concentrate (flotation) S 47-48 wt%; Fe 42–43 wt% fine particles 55% < 45µm Coarse Pyrite S 47-48 wt%; Fe 42–43 wt% coarse particles 0 6 mm

More

Bioleaching of copper ore flotation concentrates

Jan 01, 2003· The effect of pyrite addition on the kinetics of copper concentrate bioleaching was also investigated. It was established that 3% of pyrite causes an increase in the bioleaching process. In the case of ordinary flotation concentrate bioleaching, 65% of

More

Flotation Reagent an overview ScienceDirect Topics

The flotation concentrate is filtered, bagged, and sent to a smelter (Bried et al., 2000). There are six gold mines in the Australasian region that treat refractory gold ores. The largest of these is the Porgera Gold Mine in Papua New Guinea, where a pyrite–arsenopyrite flotation concentrate is

More

A novel depressant for selective flotation separation of

Sep 01, 2019· The separation of pyrite and pyrophyllite by froth flotation is difficult because pyrophyllite (the three sheet phyllosilicate) is naturally hydrophobic, easy-sliming, and easily transports to flotation concentrates, thus reducing pyrite concentrate grade [2,,,, ]. Therefore, it is almost impossible to separate pyrite and pyrophyllite without

More

The separation of chalcopyrite and chalcocite from pyrite

Apr 01, 2014· The rougher flotation concentrate was reground in a rod mill before cleaner flotation. It was found that chalcopyrite and chalcocite exhibited different flotation behavior and also affected pyrite flotation differently in cleaner flotation. The mechanism underpinning these phenomena was investigated by a range of techniques including the

More

Leaching of the arsenopyrite/pyrite flotation concentrates

The arsenopyrite/pyrite flotation concentrate, mainly studied in the hydrochloric acid medium, decomposed through the non–oxidative chemical dissolution reaction and the reductive decomposition reaction for the arsenopyrite and pyrite components, respectively. Desulphurization levels below 65% were achieved at pH

More

The depression of pyrite in selective flotation by

Pyrite is a major gangue mineral associated with galena and other valuable minerals, and it is necessary to selectively remove pyrite to upgrade the lead concentrate by froth flotation.

More

(PDF) A Brief Review of Auriferous Sulphide Flotation

Notwithstanding, in the separation of gold bearing sulphides during froth flotation, a concentrate made up of both pyrite and arsenopyrite is obtained due to their similar characteristics and

More

Chapter 7 Electrochemical Control of Pyrite-Activation by

flotation plants is to reject pyrite to produce a marketable grade concentrate. More recently, clean air regulations mandate pyrite removal from smelter feeds to reduce the emission of acid rain precursor. Pyrite, like a number of other sulfides, may be activated for more efficient flotation by interaction with dissolved heavy metals ions, e.g

More

PYRITE ROASTING, AN ALTERNATIVE TO SULPHUR BURNING

important process figures are the reaction temperature and the concentrate throughput. The pyrite concentrates can be classified as: Type Composition Grain Size Pyrite Concentrate (flotation) S 47-48 wt%; Fe 42–43 wt% fine particles 55% < 45µm Coarse Pyrite S 47-48 wt%; Fe 42–43 wt% coarse particles 0 6 mm

More

CHAPTER 7 FLOTATION OF SULPHIDE MINERALS

Flotation of pyrite is possible below pH 11 with short chain xanthates, but is depressed above about pH 11 Depression of Pyrite 1. depress pyrite enables a sphalerite concentrate to be made. Finally a lowering of pH can enable a pyrite concentrate to be made if required.

More

Selective separation of arsenopyrite from an auriferous

The industrial concentrate, used in this work, is an auriferous bulk pyrite- arsenopyrite flotation concentrate which is considered as a problematic "waste", due to its arsenic content. A positive relationship exists between the arsenic and gold contents of this product (Matis et al., 1992 ).

More

Copper and Pyrite Separation by Selective and Sequential

Metallurgical ContentThe Problem with copper-pyrite oresThe copper pyrite separation Process FlowsheetCrushing circuit of a copper pyrite oreCopper pyrite ore Grinding circuit Flotation process of Copper-Pyrite mineralsSampling The Problem with copper-pyrite ores This flowsheet, is designed for the treatment of a copper-iron sulfide ore containing appreciable values in gold. The major portion

More

Method of floatation of copper-zinc-pyrite ore (versions)

1. Method of flotation of copper-zinc-pyrite ore, including grinding in an alkaline medium, air conditioning with reagents collectors and frothers, collective copper-zinc flotation to produce collective concentrate containing copper minerals and natural-activated sphalerite, and tails, characterized in that as the collector used is supplied in the following sequence composition selective

More

Major Mines & Projects Otjihase Mine

The Otjihase concentrator is designed as a sequential flotation plant treating a base metal sulphide mineral deposit. The economic metals in the ore are copper and silver with pyrite and small amounts of gold. Historically, the flotation plant sequentially produced copper concentrate, and pyrite concentrate with silver being primarily contained

More

DPM CONTRACTS FOR SALE OF CHELOPECH PYRITE

mainly associated with the mineral pyrite, which is currently rejected in the flotation process to ensure a saleable copper concentrate. Once Bulgarian regulatory approval is received, reconfiguration of the Chelopech mill will consist of the installation of a new flotation, thickening and filtration system, creating a pyrite concentrate circuit.

More

Froth flotation Wikipedia

Froth flotation is a process for selectively separating hydrophobic materials from hydrophilic.This is used in mineral processing, paper recycling and waste-water treatment industries. Historically this was first used in the mining industry, where it was one of the great enabling technologies of the 20th century.

More

ROLE OF STARCH AND METABISUPHITE ON PURE PYRITE

depressant type and dosages at two different pHs for flotation behavior of pyrite were investigated. The flotation flow-sheet with copper ore is given in Figure 2. Three stages cleaning were applied after obtaining a rougher-copper concentrate. Pyrite was removed

More

(PDF) Improved Flotation Process Control at Newcrest's

of pyrite concentrate from the ore. Their design is the same as and concentrate from each part of the flotation circuit and the. information extracted can be used to control the grade produced.

More